Morisset Auto Dismantlers & Mechanical Repairs recommend regular servicing to keep your car performing at its best and most fuel efficient.

Our experienced mechanics offer general and logbook services for all makes and models of passenger vehicles, 4WDs, diesel and light commercial vehicles.

New vehicle logbook servicing is also one of our specialities. Using genuine parts and the highest quality fluids, our mechanics use the latest scan tools to service your vehicle.

We can take care of all of your mechanical repairs and new and used car logbook servicing without affecting your new vehicle warranty.

Signs of needing re-gassing. 

• The air conditioning isn't blowing cold air

• It's taking longer than normal to cool down the cabin

How often is re-gassing needed?

Most cars need to be recharged every two years or so. 

Car Tires typically need to be replaced every 40,000 kilometers, but this depends on driving style and road conditions. You should also check your tires' tread depth and replace them when they are worn down to the wear indicators. 

How to check

You can check your vehicle's maintenance log book to see how far you've driven.

How does an engine replacement work? 

1. Remove the old engine and its components

2. Install the new engine

3. Reconnect all the parts connected to the engine

4. Install new accessories, spark plugs, sensors, oil filters, etc.

5. Install new oxygen sensor, coolant temperature sensor and thermostat, belts and hoses

What are the costs? 

• The cost of an engine replacement can range from $5,000 to $40,000 depending on the make, model, and type of car

• The car will likely need to be off the road for about a week while the engine is being installed

Other engine repair options Rebuilding the engine, Replacing some main parts of the engine, and Overhauling the engine. 

Both the Alternator and Starter Motor can wear out over time needing repair or replacement. 

Symptoms of a starter motor problem include: Vehicle not starting, Vehicle starting slowly, and Vehicle starting intermittently. 

Starter motor 

• An electric motor that turns the engine over when the key is turned

• Receives an electric signal from the ignition switch

• Turns the engine's flywheel

• Part of the vehicle's starting system

• Designed to operate intermittently, usually for under 30 seconds before they overheat

Alternator

• An electrical machine that converts mechanical energy from the engine into electrical energy 

• Powers the car's accessories and keeps the battery charged 

• Takes mechanical power from the engine via a belt 

• Efficiency is limited by fan cooling loss, bearing loss, iron loss, copper loss, and the voltage drop in the diode bridges 

Purpose

• To remove minor imperfections and create a flat, consistent surface on the brake disc for better contact with the brake pads. 

• Tool used:

  A brake lathe, which holds the disc and uses cutting tools to shave off a thin layer of material. 

• Benefits:

  Can extend the life of brake discs, improve braking performance, reduce vibration and noise. 

• Limitations:

  Can only be done if the disc is still within the manufacturer's minimum thickness specifications. 

Maintenance

It's important to have suspension issues addressed. Shock absorbers should be replaced every 80,000 kilometres or 5 years. 

Benefits of suspension

Suspension is crucial for a comfortable and safe driving experience. 

Why do I need a clutch replacement?

• Slipping clutch: The clutch doesn't engage fully with the flywheel, so the engine revs but the car doesn't accelerate. 

• Soft or spongy clutch: The clutch pedal feels soft or spongy, or the clutch disengages without much effort. 

• Chattering clutch: The car vibrates when the clutch engages and disengages.

What causes a clutch to wear out? aggressive driving, excessive slipping, towing heavy loads, frequent stop-and-go city driving, and riding the clutch pedal. 

How long does a clutch last?

A clutch should last between 80,000 and 160,000 kilometers. 

What's involved in a clutch replacement? 

• Removing the gearbox to access the clutch assembly

• Replacing the clutch plate and pressure plate

• Checking the clutch pedal, cable, or hydraulic system

Car Battery Maintenance 

• Car batteries need regular maintenance

• Batteries lose charge over time, even when they're disconnected

How it works.

• A car battery is usually a lead-acid battery made of lead plates and lead oxide

• The plates are submerged in an electrolyte of sulfuric acid and water

• When the battery is used, a chemical reaction occurs that releases electrons

• The electrons flow through conductors to produce electricity

• When the battery is recharged, the chemical reaction reverses

What it does.

• Starts the car's engine

• Powers the car's lights, radio, air conditioning, and more

• Stabilises the voltage in the car's electrical system

In New South Wales (NSW), a pink slip is a safety inspection report for a registered vehicle, while a blue slip is a safety inspection report for an unregistered vehicle. 

Pink slip

• A yearly eSafety inspection report that verifies a vehicle is roadworthy 

• Required for most light vehicles over five years old 

• Required to renew registration or obtain new registration for vehicles that have been unregistered for less than 90 days 

• Valid for 42 days 

Blue slip

• An authorised inspection report that verifies an unregistered vehicle is safe to drive 

• Required for vehicles that have never been registered in NSW or for vehicles that have been registered in another state or country 

• Required if the car does not have NSW license plates 

• Valid for 42 days 

You'll need to provide the original hard copy of the blue slip when registering the vehicle at the service centre. 

An LPG inspection can help prevent accidents and leaks. 

What's inspected?

• External inspection: Checks for corrosion, leaks, bulging, cracking, and signs of excessive heat or cold 

• Internal inspection: Checks for rust, scale, corrosion, or any contamination 

How often are inspections required?

• LPG cylinders need to be re-tested and stamped every 10 years 

• LPG tanks need to be inspected every 10 years after installation, and every 10 years after that 

Why are inspections important? 

• Inspections help identify issues early on to prevent accidents and leaks

• You need an LPG gas certificate to sell or register a new LPG car

A "Heavy Vehicle Inspection" in mechanics NSW refers to a thorough safety check performed on a motor vehicle or trailer with a Gross Vehicle Mass (GVM) exceeding 4.5 tonnes, conducted at a designated "Heavy Vehicle Authorised Inspection Station (HVAIS)" to ensure the vehicle meets required safety standards and is roadworthy for registration renewal or to clear a defect notice; this inspection typically includes checks on brakes, tyres, lights, steering, suspension, and other critical components. 

Key points about heavy vehicle inspections in NSW:

• Who performs it:

  Inspections are carried out by accredited HVAIS stations authorised by Transport for NSW. 

• When required:

  Usually needed when renewing vehicle registration, establishing registration for a new vehicle in NSW, or when addressing a defect notice. 

• What is checked:

  A comprehensive examination of various vehicle systems including brakes, tyres, lights, steering, suspension, bodywork, and compliance with relevant heavy vehicle standards. 

• Vehicle types:

  This applies to trucks, trailers, and other vehicles with a GVM exceeding 4.5 tonnes. 

In New South Wales (NSW), Vehicle Registration is required by law and is a formal way of identifying a vehicle and its owner. 

Who needs to register a vehicle? 

• All vehicles driven or towed on NSW roads must be registered, including trailers, caravans, and motorcycles

• You can register a vehicle as an individual or in the name of an incorporated organisation

How to register a vehicle? 

• You can transfer the registration of a used vehicle into your name if the registration is current or expired less than 3 months

What are the requirements for registering a vehicle? 

• You must purchase CTP insurance (green slip) before you can register your vehicle

• Some vehicles need a safety check (pink slip) or safety and identity check (blue slip)

What's the cost of registration? 

• The cost of registration depends on whether the vehicle is used for private or business purposes